Influences of Ultrasonic Assisted Pectin Extraction with Hydrochloric and Citric Acid from Kluai Namwa (Musa ABB cv.) on Yields Analyzed by Taguchi Method

Yasinee Chakrabandhu; Sukhuntha Osiriphun; Siriwat Jinsiriwanit; Noppol Leksawasdi; Pilairuk Intipunya; Pornchai Ratchtanapan; Koranid Ngeunkaew; Kamolpat Tananchai

doi:10.14456/nujst.2019.5

Authors

Yasinee Chakrabandhu Division of food science and technology, Faculty of Agro-Industry, Chiang Mai University, Tambon Maehae, Amphor Muang, Chiang Mai, Thailand, 50100
Sukhuntha Osiriphun Division of food science and technology, Faculty of Agro-Industry, Chiang Mai University, Tambon Maehae, Amphor Muang, Chiang Mai, Thailand, 50100
Siriwat Jinsiriwanit Division of food science and technology, Faculty of Agro-Industry, Chiang Mai University, Tambon Maehae, Amphor Muang, Chiang Mai, Thailand, 50100
Noppol Leksawasdi Division of food science and technology, Faculty of Agro-Industry, Chiang Mai University, Tambon Maehae, Amphor Muang, Chiang Mai, Thailand, 50100
Pilairuk Intipunya Division of food science and technology, Faculty of Agro-Industry, Chiang Mai University, Tambon Maehae, Amphor Muang, Chiang Mai, Thailand, 50100
Pornchai Ratchtanapan Division of food science and technology, Faculty of Agro-Industry, Chiang Mai University, Tambon Maehae, Amphor Muang, Chiang Mai, Thailand, 50100
Koranid Ngeunkaew Division of food science and technology, Faculty of Agro-Industry, Chiang Mai University, Tambon Maehae, Amphor Muang, Chiang Mai, Thailand, 50100
Kamolpat Tananchai Division of food science and technology, Faculty of Agro-Industry, Chiang Mai University, Tambon Maehae, Amphor Muang, Chiang Mai, Thailand, 50100

DOI:

https://doi.org/10.14456/nujst.2019.5

Keywords:

Ultrasound-assisted extraction, UAE, banana peel, pectin extraction, Taguchi method

Abstract

Waste of Kluai Namwa is mostly left in Thailand. Pectin extraction methods have been used to be modified. Ultrasound- assisted extraction (UAE) methods were recently known to be involved in green technology. Pectin extraction was determined the conditions of the highest percentage yield of pectin from the banana peel using ultrasound under the limitation of devices. Ultrasound conditions were set under 400 watts-maximum limit with percentage of the amplitude 60 80 and 100. Extraction times were varied at 5 10 and 15 minutes. In this study, the types of acids were compared between hydrochloric and citric acid. The Taguchi method, orthogonal array was used to support systematic experiment and maximizes the desired results. The most important factor affecting the pectin yield was acid types (factor A, 30.03%) followed by exposure time (factor C, 23.18%) and ultrasonic amplitude (factor C, 19.36%). Pectin yield predictive equation was computed by statistical software as - 0.07 - 2.19 Acid type + 0.0529 Ultrasonic amplitude + 0.235 Exposure time, R-Sq (adj) = 82.7%. The results showed that the highest yield was obtained by using the condition which gave 100% of amplitude and 15 minutes of extraction time. The obtained pectin yield was 7.88%. The degree of esterification was 37.78% showed low methoxyl percentage (MeO%) as 6.17%.

References

Begum, R., Aziz, M. G., Uddin, M. B., & Yusof, Y. A. (2014). Characterization of jackfruit (Artocarpus heterophyllus) waste pectin as influenced by various extraction conditions. Agriculture and Agricultural Science Procedia, 2, 244–251. https://doi.org/10.1016/j.aaspro.2014.11.035

Canteri-Schemin, M. H., Fertonani, H. C. R., Waszczynskyj, N., & Wosiacki, G. (2005). Extraction of pectin from apple pomace. Brazilian Archives of Biology and Technology, 48, 259-266.

Chaharbaghi, E., Khodaiyan, F., Hosseini, S. S., Chaharbaghi, E., Khodaiyan, F., & Hosseini, S. S. (2017). Optimization of pectin extraction from pistachio green hull as a new source. Carbohydrate Polymers, 173, 107–113. https://doi.org/10.1016/j.carbpol.2017.05.047

Emaga, T. H., Ronkart, S. N., Robert, C., Wathelet, B., & Paquot, M. (2008). Characterisation of pectins extracted from banana peels (Musa AAA) under different conditions using an experimental design. Food Chemistry, 108, 463–471. https://doi.org/10.1016/j.foodchem.2007.10.078

Girma, E., & Worku, T. (2016). Extraction and characterization of pectin from selected fruit peel waste. International Journal of Scientific and Research Publications, 6 (2), 447-454.

Guerrero, A. B., Aguado, P. L., Sánchez, J., & Curt, M. D. (2015). GIS-Based Assessment of Banana Residual Biomass Potential for Ethanol Production and Power Generation: A Case Study. Waste and Biomass Valorization, 7, 405-415. https://doi.org/10.1007/s12649-015-9455-3

Kar, F., & Arslan, N. (1999). Characterization of orange peel and effect of sugars, l-ascorbic acid, ammonium persulfate, salts on viscosity of orange peel pectin solutions. Carbohydrate Polymers, 40, 285-291. https://doi.org/10.1016/S0144-8617(99)00063-6

Kratchanova, M., Pavlova, E., & Panchev, I. (2004). The effect of microwave heating of fresh orange peels on the fruit tissue and quality of extracted pectin. Carbohydrate Polymers, 56, 181–185. https://doi.org/10.1016/j.carbpol.2004.01.009

Kumar, A., & Chauhan, G. S. (2010). Extraction and characterization of pectin from apple pomace and its evaluation as lipase (steapsin) inhibitor. Carbohydrate Polymer, 82, 454–459. https://doi.org/10.1016/j.carbpol.2010.05.001

Liew, S. Q., Chin, N. L., & Yusof, Y. A. (2014). Extraction and characterization of pectin from passion fruit peels. Agriculture and Agricultural Science Procedia, 2, 231–236. https://doi.org/10.1016/j.aaspro.2014.11.033

Maran, J. P., Priya, B., Al-Dhabi, N. A., Ponmurugan, K., Moorthy, I. G., & Sivarajasekar, N. (2017). Ultrasound assisted citric acid mediated pectin extraction from industrial waste of Musa balbisiana. Ultrasonics Sonochemistry, 35, 204–209. https://doi.org/10.1016/j.ultsonch.2016.09.019

McDonnell, C., & Tiwari, B. K. (2017). Ultrasound: A Clean, Green Extraction Technology for Bioactives and Contaminants. Comprehensive Analytical Chemistry, 76, 111-129. https://doi.org/10.1016/bs.coac.2017.03.005

Moorthy, I. G., Maran, J. P., Ilakya, S., Anitha, S. L., Sabarima, S. P., & Priya, B. (2017). Ultrasound assisted extraction of pectin from waste Artocarpus heterophyllus fruit peel. Ultrasonics Sonochemistry, 34, 525-530. https://doi.org/10.1016/j.ultsonch.2016.06.015

Oliveira, T., Rosa, M. F., Cavalcante, F. L., Pereira, P. H. F., Moates, G. K., Wellner, N., … & Azeredo, H.M.C. (2016). Optimization of pectin extraction from banana peels with citric acid by using response surface methodology. Food Chemistry, 198, 113-118. https://doi.org/10.1016/j.foodchem.2015.08.080

Phadke, M. S. (1989). Quality Engineering Using Robust Design. Englewood Cliffs. New Jersey: Prentice Hall.

Raji, Z., Khodaiyana, F., Rezaei, K., Kiani, H., & Hosseini, S. S. (2017). Extraction optimization and physicochemical properties of pectin from melon peel. International Journal of Biological Macromolecules, 98, 709–716. http://doi.org/10.1016/j.ijbiomac.2017.01.146

Ross, P. J. (1996). Taguchi Techniques for Quality Engineering: Loss Function, Orthogonal Experiments, Parameter and Tolerance Design (2nd ed.). New York, NY: McGraw-Hill.

Santos, J. D. G., Espeleta, A. F., Branco, F., & de Assis, S. A. (2013). Aqueous extraction of pectin from sisal waste. Carbohydrate Polymers, 92, 1997-2001. https://doi.org/10.1016/j.carbpol.2012.11.089

Sun, R., & Tomkinson, J. (2002). Comparative study of lignins isolated by alkali and ultrasound-assisted alkali extractions from wheat straw. Ultrasonics Sonochemistry, 9, 85–93. https://doi.org/10.1016/S1350-4177(01)00106-7

Thakur, B. R., Singh, R. K., Handa, A. K., & Rao, M. A. (1997). Chemistry and uses of pectin—A review. Critical Reviews in Food Science & Nutrition, 37, 47–73. https://doi.org/10.1080/10408399 709527767

Xu, S. Y., Liu, J. P., Huang, X., Du, L. P., Shi, F. L., Don, R., … & Cheong, K. L. (2018). Ultrasonic-microwave assisted extraction, characterization and biological activity of pectin from jackfruit peel. LWT, 90, 577-582. https://doi.org/10.1016/j.lwt.2018.01.007

Zouambia, Y., Ettoumi, K. Y., Krea, M., & Moulai-Mostefa, N. (2017). A new approach for pectin extraction: Electromagnetic induction heating. Arabian Journal of Chemistry, 10, 480-487. https://doi.org/10.1016/j.arabjc.2014.11.011